Bridge Special Provisions

General

The Bridge Special Provisions, published by the State Bridge Office, may be used by MoDOT's internal staff, as well as consultants, and may be used by other department of transportation agencies as a reference. The Bridge Special Provisions are to be used as an aid to assist in developing Job Specific Special Provisions for statewide bridge related construction projects.

The exclusive purpose of the Bridge Special Provisions is to provide information as a convenience to those who access it. It is the users responsibility to verify the information presented is applicable to their particular project or situation.

Section	Title	Date
000	Miscellaneous
	Formatting Instructions for Job Special Provisions	08/29/05
	Job Special Provisions Table of Contents	11/13/08

104	Scope of Work
	Construction Requirements	12/01/09
	Alternate Structures	04/04/08
	Design of Pre-Engineered Structures for Grade Separations	02/29/08
	Design of Pre-Engineered Structures for Stream Crossings	02/29/08

105	Control of Work
	Cooperation Between Contractors	08/29/05

106	Control of Material
	Metric Substitution - Pipe Piles, Column Forms & Reinforcing Steel	08/29/05

216	Removals for Bridge Structures
	Match Marking Removal of Bridges	08/29/05
	Major Bridge Removal Specials	08/29/05
	Removal of Cathodic Protection System	08/29/05

501	Concrete
	Rapid Set Concrete Patching Material	12/21/09

505	Bridge Deck Concrete Wearing Surface
	Surface Sealing Low Slump Concrete	08/29/05
	Rapid Set LowP Cement High Early Strength Concrete Wearing Surface	12/21/09

622	Pavement and Bridge Surface Removal and Texturing
	Slurry and Residue Produced During Surface Treatment of PCCP and Bridge Decks DSP-06-05 (See MoDOT internet job special provisions site)	04/28/06

623	Concrete Bonding Compound, Epoxy Mortar and Epoxy Polymer Concrete Overlay
	Epoxy Polymer Concrete Overlay	05/14/09

702	Load Bearing Pile
	Static Load Testing	08/29/05
	Dynamic Pile Testing	11/12/08

703	Concrete Masonry Construction
	Clearance Gauge	08/29/05
	Cold Weather Concreting	08/29/05
	Form Liners	03/19/06
	Surface Sealing Concrete	08/29/05
	Bridge Deck Concrete Public Vehicular Traffic Restrictions	08/07/09

704	Concrete Masonry Repair
	Deck Girder End Repair	08/29/05
	Epoxy Pressure Injecting	08/29/05
	Half Concrete Filled Steel Grid Deck Repairs	08/29/05
	Total Surface Hydro Demolition	03/05/10
	Clean and Epoxy Seal	10/25/05
	Concrete Wearing Surfice Repair	09/16/09
	Hydro Surface Profiling	03/05/10

705	Prestressed Concrete Members for Bridges
	Post-Tensioned Concrete I-Girders	08/29/05

707	Conduit System on Structure
	Cathodic Protection System	08/29/05
	Electrical Grounds	08/29/05

711	Protective Coatings for Exposed Concrete Surfaces
	Dampproofing	08/29/05
	Waterproofing	08/29/05
	Waterproofing Membrane	08/19/09
	Protective Surface Treatment for Concrete- Penetrating Sealers	01/24/08
	Waterproofing Prestressed Slab Beam Ends	10/30/08

712	Structural Steel Construction
	Cleaning, Lubricating and Coating Existing Bearings	08/29/05
	Coating Galvanized Slab Drains	10/25/05
	Drainage System	06/20/08
	Earthquake Restrainers	08/29/05
	Existing Diaphragm Connection to Flange	08/29/05
	Grouting Short Column Jackets	08/29/05
	Non-Destructive Testing	05/14/07
	Pressure Grouting Long Column Jackets	08/29/05
	Rivet Removal and Replacement	08/29/05
	Slab Drain with Grate	08/29/05
	Steel Grid Floor (Half Concrete Filled)	08/29/05
	Strengthening Existing Stringers	03/10/10
	Structural Steel Protective Coating Requirements (used w/ no plans)	08/29/05
	Structural Steel Requirements	08/29/05
	Chloride Remediation Process	04/01/09
	Hinge Modification	09/21/09

716	Neoprene Bearings
	POT Bearings	08/29/05

717	Neoprene & Silicone Joing Systems
	Modular Expansion Joint System	8/29/05

718	Temporary Bridge
	Superstructure Furnished by the Contractor	08/29/05

725	Metal Pipe and Pipe-Arch Culverts
	Corrugated Metal Pipe Pile Spacers	08/29/05

727	Structural Plate Pipe and Pipe-Arch Culverts
	Pre-Engineered Structural Plate Structures	01/03/08

733	Precast Concrete Box Culverts
	Pre-Engineered Precast Concrete Structures	10/31/07

901	Highway Lighting
	Navigation Lighting System	08/29/05

1080	Structural Steel Fabrication
	Shear Connector Studs	11/12/09

1081	Coating of Structural Steel
	Overcoating of Structural Steel (System G)	08/29/05
	Coating Structural Steel-Disposal Invoices and Payment	01/19/10

For technicial support, questions or errors please contact bppl@modot.mo.gov.

Our mission is to provide a world-class transportation experience that delights our customers and promotes a prosperous Missouri.